Compositional analysis and characterization of lignocellulosic biomass from selected agricultural wastes

Authors

  • Adewale Elijah Fadeyi Chemistry Advanced Research Centre, Sheda Science and Technology Complex, P.M.B. 186 Garki, Abuja, Nigeria
  • Saheed Olatunbosun Akiode Biotechnology Advanced Research Centre, Sheda Science and Technology Complex, P.M.B. 186 Garki, Abuja, Nigeria
  • Stella A Emmanuel Chemistry Advanced Research Centre, Sheda Science and Technology Complex, P.M.B. 186 Garki, Abuja, Nigeria
  • Olajide Ebenezer Falayi Chemistry Advanced Research Centre, Sheda Science and Technology Complex, P.M.B. 186 Garki, Abuja, Nigeria

DOI:

https://doi.org/10.37134/jsml.vol8.1.6.2020

Keywords:

melon husk, mango endocarp, moringa pod, lignocellusic biomass, biofuel

Abstract

Agricultural wastes have been identified as a potential lignocellulosic biomass for bioethanol production. An accurate biomass characterization is needed to evaluate the new potential lignocelluloses biosource for biofuel production. This study evaluates the compositional analysis and characterization of three agricultural wastes (melon husk, moringa pod and mango endocarp). The samples were collected locally in Sheda Village, FCT, Abuja, Nigeria. The lignocellulose biomass composition of the samples was determined by using a proven economically viable gravimetric method and the samples were further characterized using the FTIR. The results showed that a significant amount of hemicelluloses content was found, from 19.38% to 27.74% and the highest amount was present in melon musk. The amount of cellulose ranging from 22.49% to 45.84% was found where the highest amount was found in mango endocarp. Lignin content was in the range of 22.62% to 29.87% and melon husk was shown to have the highest amount. The FTIR spectroscopic analysis showed a broad band at 3422.99 cm-1, 3422.66 cm-1, 3422.85 cm-1 (for mango endocarp, melon husk and moringa pod respectively) representing bonded –OH groups. The peak around 1637 cm-1 corresponds to C=C stretching of conjugated carboxylic acids. The aliphatic chains, -CH2- and –CH3, which form the basic structure of cellulose material, were seen at 1205.72, 1204.50 and 1206.24 cm-1. The signals at 1056.15, 1035.80 and 1055.86 cm-1 correspond to C-O-R (alcohols or esters) vibration. The results show that the samples contain significant quantity of lignocellulosic biomass. Thus, the agricultural wastes could be of valuable use in biofuel production.

Downloads

Download data is not yet available.

References

Ali, E. N. and Jamaludin, M. Z. (2015). Possibility of Producing Ethanol from Moringa Oleifera Pod Husk. Journal of Advanced Research Design. 5(1), 1-9.

Ayeni, A. O., Hymore, F. K.S.,Mudliar, N., Deskmukh, S. C., Satpute, D. B., Omoleye, J. A. and Pandey, R. A. (2013).Hydrogen peroxideand lime based oxidative pretreatment of wood waste to enhance enzymatic hydrolysis for a biorefinery: process parameters optimization using response surface methodology, Fuel, 106, 187-194.

Ayeni, A.O.,Adeeyo, O.A., Oresegun, O.M. and Oladimeji, T.E.(2015). Compositional analysis of lignocellulosic materials: Evaluation of an economically viable method suitable for woody and non-woody biomass. American Journal of Engineering Research. 4(4), 14-19

Ayotunde, E.O., Fagbenro, O.A., and Adebanyo, O.T. (2011). Toxicity of aqueous extract of Moringaolifera seed powder to Nile tilapia (Oreochromisniloticu) fingerlings. International Research Journal of Agricultural Science and Social Science. 1, 142-150

Bello, O. S., Adegoke, K. A. and Akinyunni, O. O. (2017). Preparation and characterization of a novel adsorbent from Moringaoleifera leaf. Applied Water Science. 7, 1295–1305

Blasi CD, Signorelli G, Russo CD, Rea G. (1999). Product distribution from pyrolysis of wood and agricultural residues. Industrial and Engineering Chemistry Research. 38, 2216–24.

Bodirlau, R., Teaca, C.A. and Spiridon, I. (2008). Chemical modification of beech wood: Effect on thermal stability,” Bioresources. 3(3), 789-800

Bon, E. P. S. (2007). Ethanol production via enzymatic hydrolysis of sugarcane bagasse and straw. Paper presented at the Food and Agricultural Organisation Symposium: The role of agricultural biotechnologies for production of bio-energy in developing countries, www.fao.org/biotech/presentation/bon.pdf.

Champagne, P. and Li, C. (2009). Enzymatic hydrolysis of cellulosic municipal waste water treatment process residuals as feedstock for the recovery of simple sugars. Bioresources Technolology. 100(23), 5700-5706

Chen, H. (2014). Chemical Composition and Structure of Natural Lignocellulose, Biotechnology of Lignocellulose: Theory and Practice, 25-71

Fan, M., Dai, D. and Huang, B. (2012). Fourier transform infrared spectroscopy for natural fibres. In: Mohammed Salih, Salih (Ed.), Fourier Transform – Materials Analysis. InTech. http://dx.doi.org/10.5772/35482.

Goshadrou, A., Karimi, K. and Taherzadeh, M.J. (2011). Bioethanol production from sweetsorghum bagasse by Mucorhiemalis. Industrial Crops and Products. 34 (1), 1219–1225.

Hall, M., Bansal, P., Lee, J.H., Realff, M.J. and Bommarius, A.S. (2010). Cellulose crystallinity – a key predictor of the enzymatic hydrolysis rate. FEBS J. 277 (6), 1571–1582

Himmel, M.E., Ding, S.Y., Johnson, D.K. (2007) Biomass recalcitrance: Engineering plants and enzymes for biofuels production. Science, 315, 804–807

Jeihanipour, A., Karimi, K. and Taherzadeh, M.J. (2010). Enhancement of ethanol and biogas production from high-crystalline cellulose by different modes of NMO pretreatment. Biotechnology and Bioengineering. 105, 469–476

Ju, X.H., Bowden, M., Brown, E.E. and Zhang, X. (2015). An improved X-ray diffraction method for cellulose crystallinity measurement. Carbohydrate Polymer. 123, 476–481

Karimi, K., Kheradmandinia, S. and Taherzadeh, M.J. (2006). Conversion of rice straw to sugars by dilute acid hydrolysis. Biomass and Bioenergy, 30, 247-53.

Kusch, S. and Morar, M.V. (2009). Integration of lignocellulosic biomass into renewable energy generation concepts. ProEnvironment, 2, 32-37.

Leanpolchareanchai, J., Padois, K., Falson, F., Bavovada, R., and Pithayanukul, P. (2014). Microemulsion system for topical delivery of thai mango seed kernel extract: Development, physicochemical characterisation and ex-vivo skin permeation studies. Molecules, 19(11), 17107-17129.

Li S, Xu S, Liu S, Yang C, Lu Q. (2004). Fast pyrolysis of biomass in free-fall reactor for hydrogen-rich gas. Fuel Process Technology. 85, 1201–1211.

Li, L. J., Wang, Y., Zhang, Q., Li, J., Yan, X. and Jin, J. (2008). Wheat straw burning and its associated impacts on Beijing air quality. Science in China Series D: Earth Science. 51, 403–414

Lin L, Yan R, Liu Y, Jiang W. (2010). In-depth investigation of enzymatic hydrolysis of biomass wastes based on three major components: cellulose, hemicelluloses, and lignin. Bioresources Technology. 101, 8217–8223.

Mesa, L., Gonzalez, E., Cara, C., Ruiz, E., Castro, E. and Mussatto, S. I. (2010). An approach to optimization of enzymatic hydrolysis from sugarcane bagasse based on organosolv pretreatment, Journal of Chemical Technology Biotechnology, 85, 1092-1098.

Mtui, Y.S. (2009). Recent advances in pretreatment of lignocellulosic wastes and production of value added products, African Journal of Biotechnology. 8(8), 1398-1415

O'Shea, N., Arendt, E., and Gallagher, E. (2012). Dietary fibre and phytochemical characteristics of fruit and vegetable by-products and their recent applications as novel ingredients in food products. Innovative Food Science & Emerging Technologies. 16, 1-10.

Ostovareh, S., Karimi, K. and Zamani, A. (2015). Efficient conversion of sweet sorghum stalks to biogas and ethanol using organosolv pretreatment. Industrial Crops and Products. 66, 170–177

Park, S., Baker, J.O., Himmel, M.E., Parilla, P.A. and Johnson, D.K. (2010). Cellulose crystallinity index: measurement techniques and their impact on interpreting cellulase performance. Biotechnology for Biofuels. 3, 1754–6834

Paturau, J.M. (1989) By-products of cane sugar industry. Third edition. Elsevier, Amsterdam, Netherlands

Rekhapriyadharshini (2015). A study on the Export Performance of Fresh Mangoes from India. International Journal of Interdisciplinary and Multidisciplinary Studies (IJIMS), 2 (6), 134-140.

Sanchez, R.O., Balderras,P.H., Roa, G.M., Urena, F.N., Orozco,J.V., Lugo,V.L., Flores, N.R., Eduardo, C.B.D. and Cajero, P.B. (2014). Fruit residue to ethanol, BioResources. 9(2), 1873-1885

Sarkar, N., Gosh, K.S., Bannerjee, S. and Aikat, K. (2012). Bioethanol production from agricultural wastes: An overview. Renewable Energy. 37(1), 19-27

Silvério, F.O.; Barbosa, L.C.A.; Gomide, J.L.; Reis, F.P.; Piló-Veloso, D. (2006). Methodology of extraction and determination of extractive contents in eucalypt woods. Revistaárvore, Viçosa. 30(6), 1009-1016

Sluiter, A., Hames, B. Ruiz, R., Scarlata, C., Sluiter, J., Templeton, D. and Crocker, D. (2008). Determination of structural carbohydrates andlignin in biomass: laboratory analytical procedure (LAP). Golden, CO: National Renewable Energy Laboratory.

Sluiter, J.B., Ruiz, R.O., Scarlata, C.J., Sluiter, A.D. and Templeton, D.W. (2010). Compositional Analysis of Lignocellulosic Feedstocks. Review and Description of Methods. Journal of Agricultural and Food Chemistry. 58(16), 9043-9053

Vieira, F.S. and Pasquini, C. (2014). Determination of cellulose crystallinity by terahertztime domain spectroscopy. Analitical Chemistry. 86, 3780–3786

Xu, F., Yu, J., Tesso, T., Dowell, F. and Wang, D. (2013). Qualitative and quantitative analysis of lignoicelulose biomass using infra red techniques: A mini review. Applied Energy, 104 (1), 801-809.

Zapata, B., Balmaseda, J., Fregoso-Israel, E. and Torres-Garcia, E. (2009). Thermokinetics study of orange peel in air. Journal of Thermal Analisis and Calorimetry. 98(1), 309-315.

Downloads

Published

2020-01-07

How to Cite

Fadeyi, A. E., Akiode, S. O., Emmanuel, S. A., & Falayi, O. E. (2020). Compositional analysis and characterization of lignocellulosic biomass from selected agricultural wastes. Journal of Science and Mathematics Letters, 8(1), 48–56. https://doi.org/10.37134/jsml.vol8.1.6.2020

Issue

Section

Articles